Tesla Battery Replacement Cost Explained

If you’re wondering how much it will cost to replace Tesla’s battery in 2022, you’re not alone. Tesla’s battery packs are worth investigating for both longevity and replacement cost; After all, they are the core components of Tesla! And as we covered Tesla’s battery life in a previous blog post, this time we’re aiming for that second factor: the cost of replacement.

Tesla’s parts price list is not an open book, and no official guide exists on repair or replacement costs. But with current battery prices of around $132-$135 per kWh and information from some Tesla owners who have produced a Model S or Model 3 battery replacement service bill, we can make some good guesses as to the cost of Tesla battery replacement. How much is

First, let’s explore battery replacement costs by model through the estimated value of parts and labor. After that, we’ll answer some questions about Tesla’s battery warranty, list indications that Tesla batteries may need replacing, and discuss the potential cost of replacing the battery in your search for a used Tesla. How can it affect

Tesla Model S Battery Replacement- How Much Does It Cost?

While battery replacement reports from owners of Model S states out of warranty are few and far between, we’ve found a few cases where a full battery replacement trip costs up to $20,000. It sounds like a lot, but the price drop shows that Model S battery price is somewhere in the range $12,000-$15,000,

Additional replacement parts, such as connectors and wiring, are sometimes needed, most in the $20-$200 range. Lastly, depending on whether there is damage to be repaired or any complications with the replacement, it is reportedly taking anywhere from 3 to 13 hours for a battery replacement. Since labor costs at Tesla service centers are reported to be around $175-$200 per hour, this is an additional $525-$2,600. This sounds excessive until you remember that all these workers are handing over a high voltage system, and the overhead for their insurance and facilities compliance is too high.

ground level: The cheapest estimate for an out-of-pocket, simple battery replacement on the Model S should cost $12,000-$13,000 for the battery, $100-200 for miscellaneous parts, and $500-600 for labor. That puts the grand total for a full Model S battery replacement at $13,000-$14,000.

Fun fact: At one point, Tesla considered battery swapping stations as an alternative to supercharging. They claimed they could swap out a Model S battery in about 3 minutes and were getting faster. Too bad it wasn’t sustainable; We kinda dig the idea of ​​a battery swap roadtrippin’.

Tesla Model X Battery Replacement Cost – What You Can Expect to Pay

We honestly haven’t seen any repair bills for the Model X that give details on full battery replacements, but it’s safe to assume that the price is about the same as the battery replacements on the Model S.

With a Model S repair report taking 3-13 hours for the same problem, battery repair labor costs on a Model X can run at around $500-$2,500 on a labor charge of $175-$200 per hour. These numbers really depend on the reason for replacing the battery, as the replacement itself shouldn’t be an overly complicated process.

A new Tesla battery with a 100kWh battery pack for the Model X should run well over $13,500 if we base our pricing plan only on the current $135 per kWh estimate. Since Tesla almost exclusively uses repackaged packs, the actual price should be slightly lower. This scenario puts our lowest Model X battery replacement estimate at $13,000 for the battery, $100-200 for miscellaneous parts, and a potential $500-$600 for labor. In other words, The lowest estimated price for an out-of-pocket, direct battery replacement on the Model X is about $14,000.

How much does it cost to replace a Tesla Model 3 battery?

We’ve seen at least one service receipt that puts a Model 3 battery replacement at $13,500 for just the battery pack (for a rebuilt 75 kWh battery, labor not included). With battery sizes ranging from 50kWh to 82 kWh, Current battery price estimates for the new Model 3 battery are $7000-$11,000. keep close toStill less than $13,500 on our example invoice.

Why isn’t it closer to the $5,000-$7,000 quoted by Musk in 2019 (and picked up by Google whenever someone asks what a Model 3 battery costs)? Well, he clarified that $5,000-$7,000 was per module, not per battery pack. The battery pack on the Model 3 is made up of 4 modules, so the estimated cost for pack replacement is $20,000 – $28,000. $13,500 makes sound great, doesn’t it?

As Tesla ramps up Model 3 production and continually works to improve its battery design, it’s quite possible that prices will drop dramatically over the next few years. For now, our The minimum out-of-pocket cost estimate for a complex battery replacement on a Model 3 is approximately $13,000. Will happen (assuming $12,000 for the battery alone, $100 for miscellaneous parts and $500 for labor).

Tesla Model Y Battery Replacement – Total Cost Including Labor and Spares

The cost of replacing the battery on Tesla’s Model Y is an enigma… and that’s a good thing. Reports of the Model Y needing new batteries are virtually absent.

Does it have anything to do with how new the Model Y still is? Absolutely.

However, like the Model 3, Model S and Model X, there are very few reports of abnormal degradation or out of warranty battery replacements on the Model Y.

Since the Model Y battery pack is similar in design to the Model 3, the cost of replacing the battery will also be similar. At the current estimated cost per kWh ($137), a new 75-82kWh battery pack on the Model Y will cost approximately $10,000-$12,000. With miscellaneous parts and added a labor fee of about $500 for a 3-hour replacement, A more accurate low estimate for a Model Y battery pack replacement is around $11,000-$13,000.

How do I know if my Tesla battery needs to be replaced?

Tesla’s batteries are designed to last over the body of the car. This means they must retain usable driving capability over 500,000 miles. But how do you know if a Tesla battery pack needs replacing?

Some basic warning signs are:

• Sudden drop in driving range, more than 20%
• Drop in limit over and above the 30% warranty norm
• failure to hold charge
• A notification from Tesla that there is something wrong with the battery

While this is obviously not an exhaustive list, we’d like to note that battery problems other than degradation are usually problems that send you straight to a service center (problems with charging, sudden loss of range, or full battery life). Kind of dead battery comes) pay attention). In other words, Tesla won’t have the slow build-up of issues before a battery replacement.

The good news, however, is that the data seems to favor Tesla’s battery run pretty well over time. Also, at this point in time, most Teslas are still within the terms of their battery warranties.

(A quick shout out to our friends at Gruber Motor Company! If you haven’t heard, they’re Tesla battery replacement specialists! If you need a Tesla battery out of warranty, they’re the best! Check out their latest model S battery replacement video below.)

Are Tesla batteries covered under replacement warranty?

It’s always a good idea to know exactly what the warranty will cover before the battery becomes an issue on your Tesla or if you are looking to buy a pre-owned Tesla. If you’ve read this far, you know that replacement batteries for Teslas ain’t cheap.

Covers manufacturing defects regarding Tesla high voltage batteries and related equipment 8 years and 150,000 miles (whichever comes first). This means that if a part fails, such as a battery cell or high voltage cable, Tesla will cover parts, labor and other expenses surrounding the repair (such as a loaner vehicle and, in some cases, towing expenses). ). There are a few important exceptions to the mileage limit; Pre-2020 Model S and Model X vehicles are covered for 8 years and unlimited miles (unless battery A 60kWh or 40kWh pack; then, it is 8 years / 125,000 miles,

Tesla has also added a warranty clause that covers battery replacement due to degradation. Most of Tesla’s vehicles are is covered by the warranty if the battery loses more than 30% of its original capacity during the warranty period. The exception to this clause is the original Tesla Roadster, but all first-generation Roadsters are out of their original warranty.

For more information on battery warranties, such as situations that void the warranty or the failure of a battery warranty to transfer to new owners, see our ultimate guide to Tesla warranty coverage.

Should I Be Worried About the Batteries in a Used Tesla?

If you haven’t already heard about his decision to dynamite Finland’s Tuomas Kaitanen and his 2013 Model S instead of facing a repair bill of over $22,000… well, let’s say he wasn’t happy. That the car he recently bought isn’t as big a deal as he thought. Most of the bill was reportedly for a complete battery replacement.

Catanon’s 2021 repair bid is the highest we’ve heard on a Model S, and their story is a great example of what a buyer should look for when buying a used Tesla. We have to wonder, in the case of the Catanon, what were the issues with previous repairs on the Model S? How did the previous owner(s) generally charge it? Was the repair shop (as per most reports, not a Tesla service center) paying an exact replacement cost? Would Tesla actually have certified non-Tesla shop repairs (and justified the bill) if Catalan hadn’t decided to put his money in favor of some pyrotechnics? We do not know the answer to most of these questions.

The video of Tesla’s explosion, of course, presents a sensational story that’s less about real answers and more about blowing things up. Good for entertainment, bad for real world numbers.

So should you be concerned about a used Tesla battery? We don’t think so, but like any used vehicle, it always makes sense to ask questions. In fact, a used Tesla battery deserves just as much Test As does the engine on a used internal combustion vehicle. You’d be wise to take a look at the health of Tesla’s batteries, ask the owner questions about charging habits, and learn a bit about Tesla batteries in general. For the best peace of mind, a pre-purchase inspection by a Tesla Service Center can give you the information to make an excellent decision about the battery health of the used Tesla you are considering.

The cost of a new battery on a Tesla, or any EV, is high enough Is The most expensive part of an EV, after all). However, real-world data shows that Tesla battery packs hold up exceptionally well over time and the knowledge that many Teslas are still under their original battery warranties may make a difference in your cost for a used Tesla. Discovery is not an anxious, nail-biting experience.

If you’re ready to start your search for a used Tesla Model S, Model X, Model 3, Model Y, or even a Roadster, be sure to check out our listing page. We’ve seen everything from original roadsters to practically non-powered Model Ys, with more Teslas listed daily. Whether you’re looking for something that’s still within Tesla’s battery warranty or just interested in that midnight silver metallic paint, no matter the year (hey, we love that too, we won’t judge) , you can find it on Find My Lightning!